background
x
loader
Troubleshooting
arrow By ATA By Message Color By Observed Faults By CAIMS By Tips

Select color for CAS message that you wish to troubleshoot

(WARNING)
RED MESSAGE (CAUTION)
AMBER MESSAGE (ADVISORY)
CYAN MESSAGE (STATUS)
WHITE MESSAGE Require immediate crew attention. These messages are accompanied by flashing master warning, triple chime attenson with or without voice message or dedicated tone. Require immediate crew awareness and future crew action may be required in the form of alternate system selection or performance limitation. These message are accompanied by flashing master caution and a single chime. Indicate safe or normal system operation which require crew awareness, over and above the dark cockpit philosophy. Indicate minor failures or reduction in systems capability, which require no crew action.

This page includes :

For AOG assistance contact:

CRC Montreal (YUL)
Quick Links

11/21/25

Message Overview:

Message Name:

R WSHLD HEATER/WIRING [OPEN]

Message Code:

3041017IN

Associated CAS:

R WSHLD HEAT FAIL
(Caution)

Reporting LRU: Right Windshield Temperature-Controller (WTC)
System Description: 30-41-00 - Windshield And Side Window Anti Icing
Schematic Diagram: [ G5000 ]  [ Global Express ]  [ Global XRS ] SSM 30-41-00-101 - Windshield Temperature Control System
Wiring Diagram: [ G5000 ]  [ Global Express ]  [ Global XRS ] WM 30-41-02-1_001 - Sheet 1 - Temperature Control (Right) - ALL
[ G5000 ]  [ Global Express ]  [ Global XRS ] WM 30-41-00-1_002 - Sheet 2 - Right Hand Side - ALL

Message Description:

A Right Windshield Heater/wiring has been detected OPEN.

  • Heater Current ≥11.07±1.01 A with 33% Heating Level
  • Heater Current ≥19.13±1.74 A with 100% Heating Level

Possible Causes:

  • Right Windshield and Side Window Temperature Controller (WTC) (A165)
  • Right Windshield Heater
  • Associated Wiring

Troubleshooting Tips:

Advisory Wire/Service Bulletin:

  • AW700-30-0463 - No Fault Found (NFF) initiative - Windshield Temperature Controller (WTC)

Forum Articles/Infoservice/Newsletter: None

Flight Operation Notifications Manual (FONM): None

NOTE:

Quick Links:

Removal of the Windshield and Side Window Temperature-Controller [ G5000 ]  [ Global Express ]  [ Global XRS ] AMM30-41-01-000-801
Installation of the Windshield and Side Window Temperature-Controller [ G5000 ]  [ Global Express ]  [ Global XRS ] AMM30-41-01-400-801
Removal of the Windshields [ G5000 ]  [ Global Express ]  [ Global XRS ] AMM56-10-01-000-801
Installation of the Windshields [ G5000 ]  [ Global Express ]  [ Global XRS ] AMM56-10-01-400-801
Wire Repair - Maintenance Practices - ALL [ G5000 ]  [ Global Express ]  [ Global XRS ] SPM20-12-10-02

Troubleshooting Recommendations:

  1. Remove all connectors from the right WTC. Inspect connectors and pins for damage/defects.

    1. If no defects or damage is found, reconnect the WTC connectors and continue with next step.
    2. If defects or damage is found, repair/rectify as required.

  2. Perform wiring checks between Right windshield heater and R WTC.

    1. If wiring checks are not good, repair defective wiring as required and do close out.
    2. If wiring checks are good, continue with next step.

  3. Measure the Heater resistance. The total resistance of the anti-fog coating when measured between terminal blocks shall be 11.73 Ω -15.87 Ω (at 19°C-29°C).

    1. If resistance is within range, go to step 5.
    2. If resistance is out of range, continue with next step.

  4. Replace right windshield heater.

    1. If system checks are good, do close out.
    2. If fault remains, continue with next step.

  5. Interchange the right WTC with the left WTC to confirm faulty unit and replace if required.
  6. Do close out.

Registered and/or unregistered trademarks of Bombardier Inc. or its subsidiaries. © 2015 Bombardier Inc. All rights reserved.